可见/近红外实时成像光谱仪控制系统设计 -

姓名
邮箱
手机号码
标题
留言内容
验证码

可见/近红外实时成像光谱仪控制系统设计

doi:10.37188/CO.2021-0119

天津大学微电子学院, 天津 300072

基金项目:光电信息控制和安全技术重点实验室资助项目（No. JCKY2019210C053）；泉州天津大学集成电路及人工智能研究院开放研究基金项目

详细信息

作者简介:
吴长坤（1991—），男，山东东营人，博士研究生，2013年、2016年于天津工业大学分别获得学士、硕士学位，主要从事光学控制系统设计、图像压缩及高速串行通信接口的VLSI实现等方面的研究。E-mail：tjuwuck@tju.edu.cn
张　为（1975—），男，陕西西安人，博士，教授，博士生导师，1997年、2000年、2002年于天津大学分别获得学士、硕士、博士学位，主要从事光电目标探测与跟踪、数字信号处理VLSI与通信系统设计、计算机视觉和图像处理等方面的研究。E-mail：tjuzhangwei@tju.edu.cn
郝亚喆（1997—），女，河北邯郸人，硕士研究生，2019年于东北大学获得学士学位，主要从事图像压缩关键模块硬件优化及硬件加速方面的研究。E-mail：haoyazhe@tju.edu.cn

中图分类号:TN47
计量
- 文章访问数:1140
- HTML全文浏览量:507
- PDF下载量:173
- 被引次数:0
出版历程
- 收稿日期:2021-06-04
- 修回日期:2021-07-13
- 网络出版日期:2021-08-16
- 刊出日期:2022-03-21

Design of a control system for a visible/near-infrared real-time imaging spectrometer

School of Microelectronics, Tianjin University, Tianjin 300072, China

Funds:Supported by the Key Laboratory of Optoelectronic Information Control and Security Technology (No. JCKY2019210C053); Tianjin University Open Research Foundation of Institute of Integrated Circuits and Artificial Intelligence in Quanzhou

More Information

Corresponding author:tjuwuck@tju.edu.cn

摘要

摘要:针对高光谱成像需求，设计了一套可见/近红外实时成像光谱仪。光谱仪基于声光可调谐滤波器（Acousto-Optic Tunable Filter , AOTF）分光器件进行设计，光谱带宽为1.3 μm，其中可见光相机工作在400~1000 nm波段，近红外相机工作在1000~1700 nm波段。光谱仪控制系统以现场可编程门阵列（Field Programmable Gate Array, FPGA）为核心处理单元，使用Cameralink接口采集相机数据，使用RS422串口对AOTF进行频率控制，通过AOTF同步信号与相机外触发信号相结合，实现了连续图像与多波长循环采集的一一对应，图像数据最后经过USB3.0接口传输到上位机进行实时显示。经外场测试，光谱仪成像质量良好，系统工作稳定，针对1024×1024分辨率图像，图像实时传输速率最高可达120 frame/s，满足设计要求。在实际工程应用中，该控制系统接口丰富，且可靠性高、灵活性好，具有较强的可扩展性。
- 成像光谱仪/
- 声光可调谐滤波器/
- 现场可编程门阵列/
- 可见/近红外/
- 系统设计
Abstract:A visible/near-infrared real-time imaging spectrometer is designed for hyperspectral imaging on the basis of an Acousto-Optic Tunable Filter (AOTF). Its operating band range is 1.3 μm, in which the visible light camera works in the 400−1000 nm band and the near-infrared camera works in 1000−1700 nm band. A Field-Programmable Gate Array (FPGA) is used as the core processing unit of the spectrometer control system. The Cameralink interface is used to collect camera data, the AOTF frequency is controlled by the serial port. Through the combination of AOTF synchronization signal and the trigger signal outside the camera, the one-to-one correspondence between a continuous image and multi-wavelength cyclic acquisition is realized. Finally, the image data is transmitted to the upper computer through the USB3.0 interface for real-time display. The field test shows that the imaging quality of the spectrometer is good and the system works stably. For images with a 1024×1024 resolution, the real-time transmission rate of the image can reach up to 120 frame/s, which meets the design requirements. In practical engineering applications, the control system has a rich interface, high reliability, flexible interface and strong expansibility.
- imaging spectrometer/
- Acousto-Optic Tunable Filter (AOTF)/
- Field Programmable Gate Array (FPGA)/
- visible/near-infrared/
- systematic design

HTML全文

图 1AOTF原理图

Figure 1.Schematic diagram of the AOTF

下载: 全尺寸图片幻灯片

图 2成像光谱仪结构示意图

Figure 2.Schematic diagram of the imaging spectrometer structure

下载: 全尺寸图片幻灯片

图 3（a）控制系统示意图及（b）控制系统PCB板图

Figure 3.Schematic diagram (a) and PCB drawing (b) of control system

下载: 全尺寸图片幻灯片

图 4光谱仪测试现场

Figure 4.Test-site of the spectrometer

下载: 全尺寸图片幻灯片

图 5可见光相机在不同波段的测试结果

Figure 5.Experimental results of the visible light camera at different wavebands

下载: 全尺寸图片幻灯片

图 6近红外相机在不同波段的测试结果

Figure 6.Experimental results of the near-infrared camera atdifferent wavebands

下载: 全尺寸图片幻灯片

参考文献 (20)

[1]	常凌颖, 赵葆常, 邱跃洪, 等. 声光可调谐滤波器成像光谱仪光学系统设计[J]. 光学学报,2010,30(10):3021-3026.doi:10.3788/AOS20103010.3021 CHANG L Y, ZHAO B CH, QIU Y H,et al. Optical design of imaging Spectrometer based on acousto-optic tunable filter[J].Acta Optica Sinica, 2010, 30(10): 3021-3026. (in Chinese)doi:10.3788/AOS20103010.3021
[2]	赵慧洁, 程宣, 张颖. 用于火星探测的声光可调谐滤波器成像光谱仪[J]. 光学精密工程,2012,20(9):1945-1952.doi:10.3788/OPE.20122009.1945 ZHAO H J, CHENG X, ZHANG Y. Design of acousto-optic imaging spectrometer for mars exploration[J].Optics and Precision Engineering, 2012, 20(9): 1945-1952. (in Chinese)doi:10.3788/OPE.20122009.1945
[3]	赵慧洁, 宋汪洋, 张颖, 等. 声光可调谐滤波器成像光谱仪实时预处理系统[J]. 中国光学,2013,6(4):577-583. ZHAO H J, SONG W Y, ZHANG Y,et al. Real-time pre-processing system of AOTF imaging spectrometer[J].Chinese Optics, 2013, 6(4): 577-583. (in Chinese)
[4]	曹佃生, 石振华, 林冠宇. 机载海洋改进型Dyson高光谱成像仪的研制[J]. 光学精密工程,2017,25(6):1403-1409.doi:10.3788/OPE.20172506.1403 CAO D SH, SHI ZH H, LIN G Y. Development of airborne ocean modified Dyson hyperspectral imager[J].Optics and Precision Engineering, 2017, 25(6): 1403-1409. (in Chinese)doi:10.3788/OPE.20172506.1403
[5]	张佳伦, 郑玉权, 蔺超, 等. 消像散的自由曲面棱镜光谱仪光学系统设计[J]. 中国光学,2020,13(4):842-851.doi:10.37188/CO.2019-0049 ZHANG J L, ZHENG Y Q, LIN C,et al. Design of a freeform curved prism imaging spectrometer based on an anastigmatism[J].Chinese Optics, 2020, 13(4): 842-851. (in Chinese)doi:10.37188/CO.2019-0049
[6]	樊星皓, 刘春雨, 金光, 等. 轻小型高分辨率星载高光谱成像光谱仪[J]. 光学精密工程,2021,29(3):463-473.doi:10.37188/OPE.20212903.0463 FAN X H, LIU CH Y, JIN G,et al. Small and high-resolution spaceborne hyperspectral imaging spectrometer[J].Optics and Precision Engineering, 2021, 29(3): 463-473. (in Chinese)doi:10.37188/OPE.20212903.0463
[7]	罗刚银, 王弼陡, 陈玉琦, 等. 可见近红外波段无人机载成像光谱仪设计[J]. 光子学报,2017,46(9):930001.doi:10.3788/gzxb20174609.0930001 LUO G Y, WANG B D, CHEN Y Q,et al. Design of visible near infrared imaging spectrometer on unmanned aerial vehicle[J].Acta Photonica Sinica, 2017, 46(9): 930001. (in Chinese)doi:10.3788/gzxb20174609.0930001
[8]	刘世界, 李春来, 徐睿, 等. 电子式多狭缝组合编码高光谱成像系统[J]. 光学学报,2020,40(1):0111026.doi:10.3788/AOS202040.0111026 LIU SH J, LI CH L, XU R,et al. Hyperspectral imaging system using electronic multi-slot combination coding[J].Acta Optica Sinica, 2020, 40(1): 0111026. (in Chinese)doi:10.3788/AOS202040.0111026
[9]	刘济帆, 马艳华, 张雷, 等. 基于AOTF的新型成像光谱系统[J]. 红外与工程,2013,42(11):3065-3069.doi:10.3969/j.issn.1007-2276.2013.11.035 LIU J F, MA Y H, ZHANG L,et al. New hyperspectral imaging system based on AOTF[J].Infrared and Laser Engineering, 2013, 42(11): 3065-3069. (in Chinese)doi:10.3969/j.issn.1007-2276.2013.11.035
[10]	NAG S, HEWAGAMA T, GEORGIEV G T,et al. Multispectral snapshot imagers onboard small satellite formations for multi-angular remote sensing[J].IEEE Sensors Journal, 2017, 17(16): 5252-5268.doi:10.1109/JSEN.2017.2717384
[11]	张瑞, 陈友华, 李世伟, 等. 基于双AOTF的新型成像光谱偏振探测系统[J]. 光谱学与光谱分析,2016,36(5):1549-1553. ZHANG R, CHEN Y H, LI SH W,et al. The research of spectral polarization imaging detection system based dual-AOTFs[J].Spectroscopy and Spectral Analysis, 2016, 36(5): 1549-1553. (in Chinese)
[12]	姜庆辉, 邱跃洪, 文延, 等. AOTF偏振光谱成像数据采集系统设计[J]. 红外与工程,2012,41(1):218-222.doi:10.3969/j.issn.1007-2276.2012.01.042 JIANG Q H, QIU Y H, WEN Y,et al. Design of data acquisition system for AOTF polarization spectral imaging instrument[J].Infrared and Laser Engineering, 2012, 41(1): 218-222. (in Chinese)doi:10.3969/j.issn.1007-2276.2012.01.042
[13]	陈明惠, 贾文宇, 何锦涛, 等. 双重滤波扫频光源的研制[J]. 光学精密工程,2018,26(10):2355-2362.doi:10.3788/OPE.20182610.2355 CHEN M H, JIA W Y, HE J T,et al. Development of swept source based on dual filtering[J].Optics and Precision Engineering, 2018, 26(10): 2355-2362. (in Chinese)doi:10.3788/OPE.20182610.2355
[14]	成桂梅, 刘涛, 荣鹏, 等. 多探测器数据控制与处理系统设计[J]. 红外与工程,2016,45(4):0420002.doi:10.3788/irla201645.0420002 CHENG G M, LIU T, RONG P,et al. Design of multi-detector data control and processing system[J].Infrared and Laser Engineering, 2016, 45(4): 0420002. (in Chinese)doi:10.3788/irla201645.0420002
[15]	王跃明, 韦丽清, 郎均慰, 等. 先进焦平面与光谱成像技术现状[J]. 光学与光电技术,2014,12(1):7-13.doi:10.3969/j.issn.1672-3392.2014.01.002 WANG Y M, WEI L Q, LANG J W,et al. Status of advanced focal plane arrays and spectral imaging technology[J].Optics&Optoelectronic Technology, 2014, 12(1): 7-13. (in Chinese)doi:10.3969/j.issn.1672-3392.2014.01.002
[16]	SHARMA A M, DOGRA A, GOYAL B,et al. From pyramids to state-of-the-art: a study and comprehensive comparison of visible-infrared image fusion techniques[J].IET Image Processing, 2020, 14(9): 1671-1689.doi:10.1049/iet-ipr.2019.0322
[17]	杨福臻, 陈新华, 赵知诚, 等. 面向小行星探测的可见-红外光谱成像光学系统[J]. 光学学报,2020,40(7):0722002.doi:10.3788/AOS202040.0722002 YANG F ZH, CHEN X H, ZHAO ZH CH,et al. Visible-infrared imaging spectrometer for the exploration of asteroids[J].Acta Optica Sinica, 2020, 40(7): 0722002. (in Chinese)doi:10.3788/AOS202040.0722002
[18]	冯蕾, 魏立冬, 杨雷, 等. 双通道曲面棱镜高光谱成像系统设计[J]. 光学学报,2019,39(5):0511002.doi:10.3788/AOS201939.0511002 FENG L, WEI L D, YANG L,et al. Design of double-channel hyperspectral imaging system based on curved prism[J].Acta Optica Sinica, 2019, 39(5): 0511002. (in Chinese)doi:10.3788/AOS201939.0511002
[19]	HE ZH P, WANG B Y, LV G,et al..Visible and near-infrared imaging spectrometer (VNIS) for Chang'E-3[C].Proceedings of SPIE 9263, Multispectral, Hyperspectral, and Ultraspectral Remote Sensing Technology, Techniques and Applications V, SPIE, 2014: 92630D.
[20]	陈洋君, 吴志勇, 崔明, 等. 基于MAX9259/MAX9260的CameraLink图像数据光纤传输技术[J]. 中国光学,2018,11(6):1017-1023.doi:10.3788/co.20181106.1017 CHEN Y J, WU ZH Y, CUI M,et al. CameraLink image data fiber transmission technology based on MAX9259/MAX9260[J].Chinese Optics, 2018, 11(6): 1017-1023. (in Chinese)doi:10.3788/co.20181106.1017